Effects of Temperature and Relative Humidity on Benzene Adsorption by Porous Activated Carbons from Lignocellulosic Biomass: Experimental Insights
DOI:
https://doi.org/10.24925/turjaf.v13i6.1526-1534.7585Keywords:
Chemical activation, Toxic chemical, Surface methodology, Volatile organic compoundAbstract
Investigating the contamination of indoor air with benzene is a global issue because it causes harm to humans. Gas adsorption has been applied for benzene removal from a gaseous environment, potentially threatening human health. Activated carbon (AC) has recently gained the interest of influential purification industries because of its significantly high adsorption capacity against air pollutants like benzene. A low-cost chemically-ACs (AGCACs) from lignocellulosic biomass was produced by pyrolysis (600-900 oC) of the precursor impregnated with H3PO4 activating agents (1:1, 3:1, 5:1). 5:1 H3PO4 activated carbon (AGCAC800-5) featured a high specific surface area (703 m2/g) and a large pore volume (0.547 cm3/g). Scanning electron microscope (SEM) analysis confirmed that the AGCAC800-5 exhibited enhanced total basicity. The AGCAC800-5 showed superior benzene uptakes of 105 and 92 mg/g at room temperature (22±0.3 oC) under humid conditions (40±2 and 60±2% relative humidity). It was emerging gas-solid interaction mechanisms for benzene capture with AGCACs by demonstrating high capacities correlated with high surface areas. The finding reveals that Agrostis capillaris residual biomass is a useful material for producing adsorbents, and successful testing outcomes demonstrate that AGCAC800-5 exhibited great potential to adsorb benzene vapor. Transformation of lignocellulosic biomass into AC can solve environmental issues such as agricultural residues and air pollution management, which could be regarded as a fine sorbent.
References
Bi, F., Ma, S., Gao, B., Yang, Y., Wang, L., Fei, F., ... & Zhang, X. (2023). Non-oxide supported Pt-metal-group catalysts for efficiently CO and toluene co-oxidation: Difference in water resistance and degradation intermediates. Fuel, 344, 128147. https://doi.org/10.1016/j.fuel.2023.128147
Brazil, T. R., Gonçalves, M., Junior, M. S., & Rezende, M. C. (2022). Sustainable process to produce activated carbon from Kraft lignin impregnated with H3PO4 using microwave pyrolysis. Biomass and Bioenergy, 156, 106333. https://doi.org/10.1016/j.biombioe.2021.106333
Cheng, T., Li, J., Ma, X., Zhou, L., Wu, H., & Yang, L. (2023). Behavior of VOCs competitive adsorption with water vapor in a slit-shaped phosphoric acid mesoporous activated carbon model. Separation and Purification Technology, 326, 124776. https://doi.org/10.1016/j.seppur.2023.124776
Cho, S. H., Lee, S., Kim, Y., Song, H., Lee, J., Tsang, Y. F., ... & Kwon, E. E. (2023). Applications of agricultural residue biochars to removal of toxic gases emitted from chemical plants: A review. Science of the Total Environment, 868, 161655. https://doi.org/10.1016/j.scitotenv.2023.161655
Danish, M., Pin, Z., Ziyang, L., Ahmad, T., Majeed, S., Yahya, A. N. A., ... & Khalil, H. A. (2022). Preparation and characterization of banana trunk activated carbon using H3PO4 activation: A rotatable central composite design approach. Materials Chemistry and Physics, 282, 125989. https://doi.org/10.1016/j.matchemphys.2022.125989
De Donno, A., De Giorgi, M., Bagordo, F., Grassi, T., Idolo, A., Serio, F., ... & MAPEC_LIFE Study Group. (2018). Health risk associated with exposure to PM10 and benzene in three Italian towns. International journal of environmental research and public health, 15(8), 1672. https://doi.org/10.3390/ijerph15081672
Deng, Z., Deng, Q., Wang, L., Xiang, P., Lin, J., Murugadoss, V., & Song, G. (2021). Modifying coconut shell activated carbon for improved purification of benzene from volatile organic waste gas. Advanced Composites and Hybrid Materials, 4(3), 751-760. https://doi.org/10.1007/s42114-021-00273-6
Domingo, J. L., Marquès, M., Nadal, M., & Schuhmacher, M. (2020). Health risks for the population living near petrochemical industrial complexes. 1. Cancer risks: a review of the scientific literature. Environmental research, 186, 109495. https://doi.org/10.1016/j.envres.2020.109495
Dou, Z., Wang, Y., Liu, Y., Zhao, Y., & Huang, R. (2023). Enhanced adsorption of gaseous mercury on activated carbon by a novel clean modification method. Separation and Purification Technology, 308, 122885. https://doi.org/10.1016/j.seppur.2022.122885
Duan, C., Meng, M., Huang, H., Wang, H., Ding, H., & Zhang, Q. (2023). Adsorptivity and kinetics for low concentration of gaseous formaldehyde on bamboo-based activated carbon loaded with ammonium acetate particles. Environmental Research, 222, 115364. https://doi.org/10.1016/j.envres.2023.115364
European Commission, (2008) Directive 2008/50/EC of the European Parliament and of the Council of 21 May 2008 on ambient air quality and cleaner air for Europe. Off. J. Eur. Union, 152, 1-44.
Fang, L., Norris, C., Johnson, K., Cui, X., Sun, J., Teng, Y., ... & Zhang, Y. (2019). Toxic volatile organic compounds in 20 homes in Shanghai: Concentrations, inhalation health risks, and the impacts of household air cleaning. Building and environment, 157, 309-318. https://doi.org/10.1016/j.buildenv.2019.04.047
Frilund, C., Kurkela, E., & Hiltunen, I. (2023). Development of a simplified gas ultracleaning process: experiments in biomass residue-based fixed-bed gasification syngas. Biomass Conversion and Biorefinery, 13(17), 15673-15684. https://doi.org/10.1007/s13399-021-01680-x
Fu, J., Jin, C., Zhang, J., Wang, Z., Wang, T., Cheng, X., ... & Chen, H. (2020). Pore structure and VOCs adsorption characteristics of activated coke powders derived via one‐step rapid pyrolysis activation method. Asia‐Pacific Journal of Chemical Engineering, 15(5), e2503. https://doi.org/10.1002/apj.2503
Gayathiri, M., Pulingam, T., Lee, K. T., & Sudesh, K. (2022). Activated carbon from biomass waste precursors: Factors affecting production and adsorption mechanism. Chemosphere, 294, 133764. https://doi.org/10.1016/j.chemosphere.2022.133764
Grimm, A., Chen, F., Simões dos Reis, G., Dinh, V. M., Khokarale, S. G., Finell, M., ... & Xiong, S. (2023). Cellulose fiber rejects as raw material for integrated production of Pleurotus spp. mushrooms and activated biochar for removal of emerging pollutants from aqueous media. Acs Omega, 8(6), 5361-5376. https://doi.org/10.1021/acsomega.2c06453
Grimm, A., dos Reis, G. S., Dinh, V. M., Larsson, S. H., Mikkola, J. P., Lima, E. C., & Xiong, S. (2024). Hardwood spent mushroom substrate–based activated biochar as a sustainable bioresource for removal of emerging pollutants from wastewater. Biomass Conversion and Biorefinery, 14(2), 2293-2309. https://doi.org/10.1007/s13399-022-02618-7
Guo, R., Jiang, S., Hu, M., Zhan, Y., Cheng, K., & Duan, G. (2021). Adsorption of volatile benzene series compounds by surface-modified glass fibers: kinetics, thermodynamic adsorption efficiencies, and mechanisms. Environmental Science and Pollution Research, 28, 30898-30907. https://doi.org/10.1007/s11356-020-12227-4
He, S., Chen, G., Xiao, H., Shi, G., Ruan, C., Ma, Y., ... & Yang, X. (2021). Facile preparation of N-doped activated carbon produced from rice husk for CO2 capture. Journal of colloid and interface science, 582, 90-101. https://doi.org/10.1016/j.jcis.2020.08.021
Huang, Y., Cheng, Q., Wang, Z., Liu, S., Zou, C., Guo, J., & Guo, X. (2020). Competitive adsorption of benzene and water vapor on lignite-based activated carbon: Experiment and molecular simulation study. Chemical Engineering Journal, 398, 125557. https://doi.org/10.1016/j.cej.2020.125557
International Agency for Research on Cancer, (2018). IARC Monographs on the Evaluation of Carcinogenic Risks to Humans 120 World Health Organization, Lyon, France.
Isinkaralar, K. (2023). Adsorption of gaseous naphthalene on carbonaceous sorbent: perspective of affecting factors. Biomass Conversion and Biorefinery, 1-8. https://doi.org/10.1007/s13399-023-04755-z
Isinkaralar, K. (2024). Experimental evaluation of benzene adsorption in the gas phase using activated carbon from waste biomass. Biomass Conversion and Biorefinery, 14(16), 19901-19910. https://doi.org/10.1007/s13399-023-03979-3
Isinkaralar, K., & Meruyert, K. (2023). Adsorption behavior of multi-component BTEX on the synthesized green adsorbents derived from Abelmoschus esculentus L. waste residue. Applied Biochemistry and Biotechnology, 195(8), 4864-4880.
Isinkaralar, K., Isinkaralar, O., & Bayraktar, E. P. (2024). Ecological and Health Risk Assessment in Road Dust Samples from Various Land Use of Düzce City Center: Towards the Sustainable Urban Development. Water, Air, & Soil Pollution, 235(1), 84. https://doi.org/10.1007/s11270-023-06879-4
Isinkaralar, K., Nurmakova, S.M. (2023). Does agricultural biomass matter for environmental sustainability? Enhanced adsorption capacity of BTEX mixture using powdered activated carbon by agricultural biomass. Biomass Conversion and Biorefinery, 1-10. https://doi.org/10.1007/s13399-023-04990-4
Isinkaralar, O., Isinkaralar, K., & Sevik, H. (2025). Health for the future: spatiotemporal CA-MC modeling and spatial pattern prediction via dendrochronological approach for nickel and lead deposition. Air Quality, Atmosphere & Health, 1-13. https://doi.org/10.1007/s11869-025-01702-x
Isinkaralar, O., Rajfur, M., Isinkaralar, K., & Świsłowski, P. (2025). Contamination degree and health implications of indoor air pollution: Operating field measurements in market environments. Science of The Total Environment, 969, 178946. https://doi.org/10.1016/j.scitotenv.2025.178946
Joshi, S., Shrestha, S., & Shrestha, B. (2021). Activated carbon from various agricultural wastes by H3PO4 activation: Preparation and characterization. Chemical Engineering & Technology, 44(12), 2327-2332. https://doi.org/10.1002/ceat.202000327
Kim, W. K., Vikrant, K., Younis, S. A., Kim, K. H., & Heynderickx, P. M. (2023). Metal oxide/activated carbon composites for the reactive adsorption and catalytic oxidation of formaldehyde and toluene in air. Journal of Cleaner Production, 387, 135925. https://doi.org/10.1016/j.jclepro.2023.135925
Koohestani, M., Salem, A., & Salem, S. (2023). Decolorization of corn syrup in a dynamic system by activated carbon bed: Microwave-assisted impregnation of H3PO4 over cherry and date stones for efficient purification. Sustainable Chemistry and Pharmacy, 36, 101298. https://doi.org/10.1016/j.scp.2023.101298
Lashaki, M. J., Kamravaei, S., Hashisho, Z., Phillips, J. H., Crompton, D., Anderson, J. E., & Nichols, M. (2023). Adsorption and desorption of a mixture of volatile organic Compounds: Impact of activated carbon porosity. Separation and Purification Technology, 314, 123530. https://doi.org/10.1016/j.seppur.2023.123530
Li, A. J., Pal, V. K., & Kannan, K. (2021). A review of environmental occurrence, toxicity, biotransformation and biomonitoring of volatile organic compounds. Environmental Chemistry and Ecotoxicology, 3, 91-116. https://doi.org/10.1016/j.enceco.2021.01.001
Liu, Z., Wang, Z., Chen, H., Cai, T., & Liu, Z. (2021). Hydrochar and pyrochar for sorption of pollutants in wastewater and exhaust gas: A critical review. Environmental Pollution, 268, 115910. https://doi.org/10.1016/j.envpol.2020.115910
Liu, Z., Xie, S., Zhou, H., Zhao, L., Yao, Z., Fan, H., ... & Yang, G. (2023). Organic contaminants removal and carbon sequestration using pig manure solid residue-derived biochar: A novel closed-loop strategy for anaerobic liquid digestate. Chemical Engineering Journal, 471, 144601. https://doi.org/10.1016/j.cej.2023.144601
Loomis, D., Guyton, K. Z., Grosse, Y., El Ghissassi, F., Bouvard, V., Benbrahim-Tallaa, L., ... & Straif, K. (2017). Carcinogenicity of benzene. The Lancet Oncology, 18(12), 1574-1575. https://doi.org/10.1016/S1470-2045(17)30832-X
Lu, S., Huang, X., Tang, M., Peng, Y., Wang, S., & Makwarimba, C. P. (2021). Synthesis of N-doped hierarchical porous carbon with excellent toluene adsorption properties and its activation mechanism. Environmental Pollution, 284, 117113. https://doi.org/10.1016/j.envpol.2021.117113
Lu, Z., Li, C., Jing, Z., Ao, X., Chen, Z., & Sun, W. (2021). Implication on selection and replacement of granular activated carbon used in biologically activated carbon filters through meta-omics analysis. Water Research, 198, 117152. https://doi.org/10.1016/j.watres.2021.117152
Ma, X., Wu, Y., Fang, M., Liu, B., Chen, R., Shi, R., ... & Li, L. (2022). In-situ activated ultramicroporous carbon materials derived from waste biomass for CO2 capture and benzene adsorption. Biomass and Bioenergy, 158, 106353. https://doi.org/10.1016/j.biombioe.2022.106353
MacDermid-Watts, K., Pradhan, R., & Dutta, A. (2021). Catalytic hydrothermal carbonization treatment of biomass for enhanced activated carbon: a review. Waste and Biomass Valorization, 12, 2171-2186. https://doi.org/10.1007/s12649-020-01134-x
Marquès, M., Domingo, J. L., Nadal, M., & Schuhmacher, M. (2020). Health risks for the population living near petrochemical industrial complexes. 2. Adverse health outcomes other than cancer. Science of the total environment, 730, 139122. https://doi.org/10.1016/j.scitotenv.2020.139122
Mbarki, F., Selmi, T., Kesraoui, A., & Seffen, M. (2022). Low-cost activated carbon preparation from Corn stigmata fibers chemically activated using H3PO4, ZnCl2 and KOH: Study of methylene blue adsorption, stochastic isotherm and fractal kinetic. Industrial Crops and Products, 178, 114546. https://doi.org/10.1016/j.indcrop.2022.114546
Meadows, D. A., Clouse, D. E., Adhikari, S., & Davis, V. A. (2023). Prediction of structural properties of activated carbons derived from lignocellulosic biomass components using mixture design of experiments. Materials Chemistry and Physics, 303, 127715. https://doi.org/10.1016/j.matchemphys.2023.127715
Mousavi, M., Aldagari, S., Crocker, M. S., Ackerman-Biegasiewicz, L. K., & Fini, E. H. (2023). Iron-rich biochar to adsorb volatile organic compounds emitted from asphalt-surfaced areas. ACS Sustainable Chemistry & Engineering, 11(7), 2885-2896. https://doi.org/10.1021/acssuschemeng.2c06292
Neme, I., Gonfa, G., & Masi, C. (2022). Preparation and characterization of activated carbon from castor seed hull by chemical activation with H3PO4. Results in Materials, 15, 100304. https://doi.org/10.1016/j.rinma.2022.100304
Phyo, S., Kim, S., Lee, H., Han, S. S., Oh, Y., & Lee, J. (2023). Adsorption enhancement of hazardous odor gas using controlled thermal oxidation of activated carbon. Journal of Cleaner Production, 393, 136261. https://doi.org/10.1016/j.jclepro.2023.136261
Sarigiannis, D. A., Gotti, A., & Karakitsios, S. P. (2019). Indoor air and public health. In Management of emerging public health issues and risks (pp. 3-29). Academic Press. https://doi.org/10.1016/B978-0-12-813290-6.00001-9
Serafin, J., Dziejarski, B., Junior, O. F. C., & Sreńscek-Nazzal, J. (2023). Design of highly microporous activated carbons based on walnut shell biomass for H2 and CO2 storage. Carbon, 201, 633-647. https://doi.org/10.1016/j.carbon.2022.09.013
Sessa, F., Merlin, G., & Canu, P. (2022). Pine bark valorization by activated carbons production to be used as VOCs adsorbents. Fuel, 318, 123346. https://doi.org/10.1016/j.fuel.2022.123346
Settimo, G., Manigrasso, M., & Avino, P. (2020). Indoor air quality: A focus on the European legislation and state-of-the-art research in Italy. Atmosphere, 11(4), 370. https://doi.org/10.3390/atmos11040370
Shen, X., Ou, R., Lu, Y., Yuan, A., Liu, J., Hu, X., ... & Yang, F. (2020). Engineering Adsorption Case for Efficient Capture of VOCs Using Biomass‐based Corncobs via a Carbonized Strategy. ChemistrySelect, 5(29), 9162-9169. https://doi.org/10.1002/slct.202002086
Shi, G., He, S., Chen, G., Ruan, C., Ma, Y., Chen, Q., ... & Yang, X. (2022). Crayfish shell-based micro-mesoporous activated carbon: Insight into preparation and gaseous benzene adsorption mechanism. Chemical Engineering Journal, 428, 131148. https://doi.org/10.1016/j.cej.2021.131148
Suresh, S., Kante, K., Fini, E. H., & Bandosz, T. J. (2019). Combination of alkalinity and porosity enhances formaldehyde adsorption on pig manure-derived composite adsorbents. Microporous and Mesoporous Materials, 286, 155-162. https://doi.org/10.1016/j.micromeso.2019.05.034
Tang, M., Huang, X., Peng, Y., & Lu, S. (2020). Hierarchical porous carbon as a highly efficient adsorbent for toluene and benzene. Fuel, 270, 117478. https://doi.org/10.1016/j.fuel.2020.117478
Tham, K. W. (2016). Indoor air quality and its effects on humans—A review of challenges and developments in the last 30 years. Energy and buildings, 130, 637-650. https://doi.org/10.1016/j.enbuild.2016.08.071
Trinh, T. K., Tsubota, T., Takahashi, S., Mai, N. T., Nguyen, M. N., & Nguyen, N. H. (2020). Carbonization and H3PO4 activation of fern Dicranopteris linearis and electrochemical properties for electric double layer capacitor electrode. Scientific Reports, 10(1), 19974. https://doi.org/10.1038/s41598-020-77099-7
Tu, W., Liu, Y., Xie, Z., Chen, M., Ma, L., Du, G., & Zhu, M. (2021). A novel activation-hydrochar via hydrothermal carbonization and KOH activation of sewage sludge and coconut shell for biomass wastes: Preparation, characterization and adsorption properties. Journal of Colloid and Interface Science, 593, 390-407. https://doi.org/10.1016/j.jcis.2021.02.133
US Environmental Protection Agency (USEPA), (1999). Compendium Method TO-17 determination of volatile organic compounds in ambient air using active sampling onto sorbent tubes. U.S. EPA Technical Assistance Document. EPA/625/R-96/010b.
Valencia, A., Muñiz-Valencia, R., Ceballos-Magaña, S. G., Rojas-Mayorga, C. K., Bonilla-Petriciolet, A., González, J., & Aguayo-Villarreal, I. A. (2022). Cyclohexane and benzene separation by fixed-bed adsorption on activated carbons prepared from coconut shell. Environmental Technology & Innovation, 25, 102076. https://doi.org/10.1016/j.eti.2021.102076
Wallace, R., Suresh, S., Fini, E. H., & Bandosz, T. J. (2017). Efficient air desulfurization catalysts derived from pig manure liquefaction char. C, 3(4), 37. https://doi.org/10.3390/c3040037
Wang, Y. H., Bayatpour, S., Qian, X., Frigo-Vaz, B., & Wang, P. (2021). Activated carbon fibers via reductive carbonization of cellulosic biomass for adsorption of nonpolar volatile organic compounds. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 612, 125908. https://doi.org/10.1016/j.colsurfa.2020.125908
Xie, L., Meng, Y., Wang, Q., Zhang, G., Xie, H., & Zhou, G. (2022). Zanthoxylum bungeanum branches activated carbons with rich micropore structure prepared by low temperature H3PO4 hydrothermal pretreatment method for toluene adsorption. Diamond and Related Materials, 130, 109474. https://doi.org/10.1016/j.diamond.2022.109474
Xuan, L., Ma, Y., Xing, Y., Meng, Q., Song, J., Chen, T., ... & Gao, P. (2021). Source, temporal variation and health risk of volatile organic compounds (VOCs) from urban traffic in harbin, China. Environmental pollution, 270, 116074. https://doi.org/10.1016/j.envpol.2020.116074
Yang, Y., Jie, B., Zhai, Y., Zeng, Y., Kang, J., Cheng, G., & Zhang, X. (2024). Performance and mechanism of efficient activation of peroxymonosulfate by Co-Mn-ZIF derived layered double hydroxide for the degradation of enrofloxacin. Journal of Molecular Liquids, 394, 123723. https://doi.org/10.1016/j.molliq.2023.123723
Yao, F., Ye, G., Peng, W., Zhao, G., Wang, X., Wang, Y., ... & Ye, D. (2023). Preparation of activated biochar with adjustable pore structure by hydrothermal carbonization for efficient adsorption of VOCs and its practical application prospects. Journal of Environmental Chemical Engineering, 11(2), 109611. https://doi.org/10.1016/j.jece.2023.109611
Zakaria, R., Jamalluddin, N. A., & Bakar, M. Z. A. (2021). Effect of impregnation ratio and activation temperature on the yield and adsorption performance of mangrove based activated carbon for methylene blue removal. Results in Materials, 10, 100183. https://doi.org/10.1016/j.rinma.2021.100183
Zhang, X., Shi, X., Zhao, Q., Li, Y., Wang, J., Yang, Y., ... & Liu, N. (2022). Defects controlled by acid-modulators and water molecules enabled UiO-67 for exceptional toluene uptakes: An experimental and theoretical study. Chemical Engineering Journal, 427, 131573. https://doi.org/10.1016/j.cej.2021.131573
Zheng, G., Wei, K., Kang, X., Fan, W., Ma, N. L., Verma, M., ... & Ge, S. (2023). A new attempt to control volatile organic compounds (VOCs) pollution-modification technology of biomass for adsorption of VOCs gas. Environmental Pollution, 122451. https://doi.org/10.1016/j.envpol.2023.122451
Zięzio, M., Charmas, B., Jedynak, K., Hawryluk, M., & Kucio, K. (2020). Preparation and characterization of activated carbons obtained from the waste materials impregnated with phosphoric acid (V). Applied nanoscience, 10, 4703-4716. https://doi.org/10.1007/s13204-020-01419-6
Downloads
Published
How to Cite
Issue
Section
License
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
